駕駛混凝土自上料攪拌車要避免的問題
混凝土自上料攪拌車是一種自動上料的攪拌車類型，可以有效節省人力的使用，成為各個建筑廠家所喜愛的一種攪拌車類型，下面混凝土自上料攪拌車廠家?guī)鷣?lái)看一下駕駛混凝土自上料攪拌車要避免的問題。
The concrete self loading mixer is a type of mixer with automatic loading, which can effectively save manpower and become a favorite type of mixer for various construction manufacturers. The manufacturer of the concrete self loading mixer will show you the problems to avoid when driving the concrete self loading mixer.
一、過度熱車
1、 Excessive hot car
不管是冬季還是其它季節，有很多車主都習慣采取原地怠速熱車的方式，熱車一段時間再行駛，覺得混凝土自上料攪拌車，這時性能佳。但事實上，原地怠速熱車不僅效果有限，還浪費汽油和時間。
No matter in winter or other seasons, many car owners are used to idling the hot car in situ. The hot car will drive for a period of time, and they think that the concrete self loading mixer has good performance at this time. But in fact, the hot car idling in place not only has limited effect, but also wastes gasoline and time.
當引擎在沒有負荷的狀態下，溫度的爬升是相當緩慢的，也就是說，引擎在怠速狀態下需要很長的時間才能達到正常的工作溫度。
When the engine is under no load, the temperature climbs very slowly, that is to say, it takes a long time for the engine to reach its normal operating temperature at idle speed.
正確的做法應當是混凝土自上料攪拌車，原地?zé)彳?0秒左右后，立即上路行駛。但由于此時引擎及驅動系統都尚未達到正常的工作溫度，仍應將轉速控制在約2000轉/分鐘之內，待水溫達到正常后方可高轉速運行。
The correct method should be that the concrete should be loaded from the mixer truck, and the truck should be warmed up in place for about 30 seconds before driving on the road. However, since the engine and drive system have not reached the normal operating temperature at this time, the speed should still be controlled within about 2000 rpm, and the high speed operation can be started only after the water temperature reaches normal.
二、熄火后仍使用電器設備
2、 Use electrical equipment after flameout
一旦混凝土自上料攪拌車，熄火，蓄電池就處于只放電不充電的工作狀態。所以如果在長時間熄火后仍然一直在使用車內大功率用電器，比如開著車輛大燈、停車在路邊長時間聽音樂等等，這樣可能很快導致蓄電池放電、混凝土自上料攪拌車，無法啟動的嚴重后果。
Once the concrete is extinguished from the charging mixer, the battery will be in the working state of only discharging but not charging. Therefore, if the high-power electrical appliances in the vehicle are still used after a long time of flameout, such as driving the headlights, parking at the roadside for a long time to listen to music, etc., this may soon lead to battery discharge, concrete self loading mixer, and serious consequences of failure to start.
三、油箱見底后才加油
3、 Refuel after the fuel tank bottoms out
有人比較懶，有人是很少去注意油箱刻度，直到油箱警示燈亮起后還會再行駛一段距離再去加油?？墒怯袝r(shí)燃油警示燈亮起后再去找加油站時，有可能出現附近沒有加油站的情況，弄得手忙腳亂。而且經常出現這樣的情況的話，混凝土自上料攪拌車，的油泵壽命可能會大大降低。
Some people are lazy, and some people seldom pay attention to the fuel tank scale. They will drive a certain distance to refuel until the fuel tank warning light is on. However, sometimes when the fuel warning light lights up and then goes to the gas station, there may be no gas station nearby, causing confusion. In addition, if this happens frequently, the service life of the oil pump of the concrete self loading mixer may be greatly reduced.
但是它的工作并不僅僅局限于混凝土的攪拌工作，還包括混凝土的運輸工作，由于車輛的結構比較特殊，在駕駛的過程中是很容易發生一些危險事故的，所以以上就是要避免的問題，希望您認真閱讀，關注我們http://m.zvmc.cn帶你了解更多事項！
However, its work is not limited to concrete mixing, but also concrete transportation. Due to the special structure of the vehicle, it is easy to cause some dangerous accidents during driving, so the above are the problems to avoid. I hope you can read carefully and pay attention to us http://m.zvmc.cn Learn more!
