攪拌車駕駛時要注意許多類難題了
假如駕駛員在攪拌車駕駛時的實際操作不善，就會造成翻車、液壓油泵、電機、減速器過快損壞乃出現嚴重危害。下列全自動攪拌車廠家為大伙兒梳理了一些開攪拌車要留意的難題，期待能幫上大伙兒。
If the driver's actual operation when driving the mixer truck is not good, it will cause rollover, hydraulic oil pump, motor and reducer to be damaged too quickly and even cause serious harm. The following full-automatic mixer truck manufacturers have sorted out some problems that you should pay attention to when driving a mixer truck, and look forward to helping you.
攪拌車運輸攪拌好的混凝土?xí)r，攪拌筒轉速比為2-10轉/分，在運送全過程中，平整地面上攪拌筒轉速比確保在2-3轉/分，行車在側傾傾斜度超過50的地面，或上下?lián)u晃很大的地面時，應終止攪拌轉動，待實時路況轉好后再修復攪拌轉動。
When the mixer truck transports the mixed concrete, the speed ratio of the mixing drum is 2-10 rpm. During the whole process of transportation, the speed ratio of the mixing drum on the flat ground is ensured to be 2-3 rpm. When the truck is on the ground with a side slope of more than 50 or the ground with a large shaking up and down, the mixing operation shall be stopped, and the mixing operation shall be repaired after the real-time road conditions are improved.
全自動攪拌車運送混凝土的時間不可以超過攪拌站要求的時間。運送混凝土中途，攪拌筒不可長期轉停，防止混凝土造成混凝土離析狀況。駕駛員應常常觀查混凝土狀況，出現異常立即通告調度，申請辦理作出。
The time for the full-automatic mixer to transport concrete shall not exceed the time required by the mixing station. During the transportation of concrete, the mixing drum shall not be stopped for a long time to prevent concrete segregation caused by concrete. The driver shall often observe and check the concrete condition. In case of any abnormality, the driver shall immediately notify the dispatching center and apply for handling to solve it.
攪拌車車?yán)锱溆谢炷習r，在現場停滯不前時間不可超過1小時，如請求超時應該馬上規定當場責任人給與妥善處理。
When the mixer truck is equipped with concrete, the time when the mixer truck stops at the site shall not exceed 1 hour. In case of request for overtime, the person in charge on the site shall be required to handle it properly.
攪拌車運送混凝土混凝土塌落度不可小于8cm。從混凝土入罐到排出來，平均氣溫高時不可超過2鐘頭務必排出來，連陰雨天氣溫度低時，不可超過2.5鐘頭。
When concrete is transported by mixer truck, the concrete slump shall not be less than 8cm. From the time of concrete pouring into the tank to the time of discharging, the average temperature shall not exceed 2 hours and must be discharged. When the temperature is low in rainy days, the average temperature shall not exceed 2.5 hours.
全自動攪拌車運送混凝土?xí)r，汽車轉速在1000-1400轉/分范疇內工作中，以使柴油發動機有較大扭距，在運送混凝土全過程中，時速不可超過40km/h，以保駕駛。
When the full-automatic mixer truck is transporting concrete, the speed of the truck is within the range of 1000-1400 rpm, so that the diesel engine has a large torque. During the whole process of transporting concrete, the speed shall not exceed 40km / h to ensure safe driving.
全自動攪拌車工作中結束，應把攪拌筒內部和車體清理整潔，不可以使剩下的混凝土留到筒內。
After the work of the full-automatic mixer truck is completed, the interior of the mixer drum and the vehicle body shall be cleaned and tidy, and the remaining concrete shall not be left in the drum.
全自動攪拌車在離心水泵工作中時，嚴禁高轉速，持續應用時不要超過15分鐘。
When the full-automatic mixer is working in the centrifugal pump, it is strictly prohibited to rotate at high speed, and the continuous application shall not exceed 15 minutes.
全自動攪拌車儲水箱的水流量要常常維持放滿，以便急需，冬天關機后，應將儲水箱、離心水泵、自來水管、攪拌筒內的水放凈，并停到朝陽區、不存水的地區，以防凍裂機械設備。
The water flow of the storage tank of the full-automatic mixer shall be kept full to meet the urgent need. After shutdown in winter, the water in the storage tank, centrifugal water pump, water supply pipe and mixing drum shall be drained and stopped in Chaoyang District and areas without water to prevent the mechanical equipment from cracking.
攪拌車在冬天應立即安裝保溫套，并應用汽車防凍液對攪拌車多方面維護，依據天氣變化更換汽柴油型號，保證機械設備的一切正常應用。
In winter, the mixer truck shall be immediately installed with thermal insulation jacket, and the truck antifreeze shall be used to maintain the mixer truck in various aspects. The gasoline and diesel models shall be changed according to the weather changes to ensure all normal applications of mechanical equipment.
在查驗、維修全自動攪拌車液壓傳動系統一部分時，應以柴油發動機和液壓油泵在沒有壓力的狀況下開展。更多注意事項您可來我們網站http://m.zvmc.cn咨詢了解！
When inspecting and repairing a part of the hydraulic transmission system of the full-automatic mixer truck, the diesel engine and hydraulic oil pump shall be carried out without pressure. For more information, please visit our website http://m.zvmc.cn Consult and understand!
